Skip to main content

O-Ringing the Block and Heads for Higher Compression Engines HOWTO

I found some useful advice in this forum thread from user AK's REX.

"To my understanding o-ringing the block or the head prove to be about equally effective. That said I would say it depends if you want to have receiver grooves machined. The most conventional method is to machine and o-ring the block, then machine receiver grooves opposite the o-rings in the heads. I guess it can probably be done in reverse fashion as well.
As far as the receiver grooves are concerned, it not only helps in high compression and or boosted applications, but helps wet motors from losing fluid which is a common problem with copper head gaskets. It allows the o-ring to literally push the gasket into the receiver groove to provide a better seal. Speaking of copper gaskets here is a bit of info from SCE regarding this stuff;
O-ring grooves may be cut in either the block or cylinder head. When using copper head gaskets thinner than .050, O-ring height should be no more than 25% of gasket thickness. For instance, the proper dimensions for an .043 thick gasket using .041 wire would be; a .038 to .040 groove width (provides a .001 interference fit), and a .032 groove depth (leaves .008-.010 of the wire protruding above the deck). This machining can be done at most high performance machine shops.

When receiver grooves are necessary, alignment of O-ring and receiver groove is critical, as is the depth and width of the receiver groove. Generally receiver groove depth should be 75% of the O-ring protrusion and the receiver groove should be 1.5 times the wire width. Example: If the O-ring is .041 wide and .015 above the deck; receiver groove should be .012 deep and .060 wide.

While the machining of O-ring and receiver grooves must be done by a machinist, the installation of the O-ring wire can be done by anyone, using common hand tools. When tapping O-ring wire into the groove, use care to avoid denting the wire. SCE provides an O-ring installation kit, (SCE PART #31542) which includes instructions, an installation tool and O-ring wire. When cutting stainless O-ring wire, file the ends square to provide the tightest possible seal."

Source: NASIOC Forums

Comments

Popular posts from this blog

A Heat Insulation Spray-on Coating Alternative to Lizard Skin.

One of the well-known spray-on heat-shield products is Lizard Skin. From their website, “LizardSkin Ceramic Insulation (CI) is an advanced spray on thermal coating that consists of a water-based composition of high-grade acrylic binders with ceramic insulation particles to create a thermal barrier.” The Material Safety Data Sheet (commonly referred to as the MSDS) can be found here . This sheet shows the composition of Lizard Skin as: 1 - Water 7732-18-5 40-50% 2 - Resin Polymer 00-00-00 20-30% 3 - Trade Secret Insulation Media 10-20% 4 - Carbon Black 1333-86-4 5-10% 5 - Extender Pigment 1317-65-3 1-5% It’s relatively expensive at $200 for two gallons. They sell a special gun ($120) to spray it on although it can be applied with a brush or roller. Substitutes It's possible to make your own for much less cost. 1 – High solids white latex ceiling paint. 2 - Acrylic Polymer Resin - increases paint flow and durability. One source is Acri-Flow

WTF is a Franzinator?

Sometimes the most useful things have the oddest names. Take the Franzinator, for instance. Named after Franz©, its curmudgeonly inventor, the Franzinator is a device used to separate moisture from compressed air. Having moisture in compressed air is not a a good thing, especially in painting where it contaminates the painted surface, or in media blasting where it causes the media to clump and not work as well. As well as causing rust in the air tanks and air tools, moisture is best removed. A number of methods have been developed from expensive refrigerated driers used to pre-condition air before it gets to the compressor, to simple mechanical separators that sit in the air line between the tanks and the air tool. Here is a tank that uses a chemical desiccant to dry the air. There are also ways to install the air lines that are intended to either cause moisture to condense or collect before it is sent to the air tool. A non-mechanical separator causes the moisture in the hotte

Keeping Your Compressor Quiet

Air compressors are noisy machines. The two most commonly used ways to quiet them down are to locate the air intake outside (not good for the neighbors) or to build some type of enclosure with sound deadening material inside; that usually causes overheating problems due to poor circulation. The best solution is to construct a silencer that uses the same principles as a gun silencer. But isn't that illegal? Only if you use it on a gun. We're using it on an air compressor. Still, this topic seems to be controversial, mostly by people who have a bury-your-head-in-the-sand approach to security and safety. Here are the materials: Pipe the same size the air compressor port will use, 16"-18" long. Some exhaust pipe, the same length as the other pipe. Some washers you have to make with a hole saw, enough to put one on each end and one every 1-1/2" that will fit around the air compressor intake port pipe and fit inside the exhaust pipe. Steel wool to fit betwe